Cocoa pod-derived biochar for Ibuprofen and Diclofenac adsorption: a low-cost and reusable adsorbent
Abstract
This study investigates the adsorption potential of biochar derived from cocoa pod husks, both in its raw form and after nitric acid-functionalization, for the removal of two common pharmaceutical pollutants, diclofenac and ibuprofen, from aqueous solutions. The biochars were characterized using BET, XRD, SEM, FTIR, and TGA-DTG techniques. Acid modification significantly enhanced the surface area (235.50 m2 g-1 vs. 213.77 m2 g-1), thereby increasing the availability of active sites for adsorption. Morphological analysis revealed irregular, porous structures favorable for pollutant trapping. Adsorption kinetics followed a pseudo-second-order model, suggesting chemisorption as the dominant mechanism, while isotherm modelling indicated a combination of physical and chemical interactions, suggesting multi-mode adsorption. Maximum adsorption occurred under highly acidic conditions (pH = 1 for diclofenac, pH = 2 for ibuprofen). Notably, the biochar recovered 63% of its capacity in the first reuse cycle, though performance declined progressively to 39% by the third cycle. These findings position cocoa pod biochar as a cost-effective, sustainable, and reusable adsorbent for pharmaceutical-contaminated water, offering a high-value application for agricultural waste in water purification systems. This research underscores the value of transforming agricultural waste into innovative adsorbents that can help address pollution challenges in wastewater management on a practical scale.
Keywords
Full Text:
PDFReferences
O. El Mountassir, M. Bahir, D. Ouazar, A. Chehbouni and P. M. Carreira, Temporal and spatial as-sessment of groundwater contamination with nitrate using nitrate pollution index (NPI), groundwater pollution index (GPI), and GIS (case study: Essaouira basin, Morocco), Environ. Sci. Pollut. Res, 2022, 17, 17132–17149.
A. Naima, F. Ammar and O. Abdelkader, Development of a novel and efficient biochar produced from pepper stem for effective ibuprofen removal, Bioresource Technol, 2022, 347, 126685.
R. B. N. Lekene, N. M. T. Matemb, M. N. A. Fetzer, T. Strothmann, N. J. Nsami and C. Janiak, The efficient removal of ibuprofen, caffeine, and bisphenol A using engineered egusi seed shells biochar: Adsorption kinetics, equilibrium, thermodynamics, and mechanism, Environmental Science and Pollu-tion Research, 2023, 37, 29377.
P. V. Viotti, W. M. Moreira, O. A. Andreo dos Santos, R. Bergamasco, A. M. Salcedo Vieira and M. F. Vieira, Diclofenac removal from water by adsorption on Moringa oleifera pods and activated carbon: Mechanism, kinetic and equilibrium study, Journal of Cleaner Production, 2019.
S. Álvarez-Torrellas, A. Rodríguez, G. Ovejero and J. García, Comparative adsorption performance of ibuprofen and tetracycline from aqueous solution by carbonaceous materials, Chemical Engineering Journal, 2016, 283, 936–947.
B. N. Bhadra, I. Ahmed, S. Kim and S. H. Jhung, Adsorptive removal of ibuprofen and diclofenac from water using metal-organic framework-derived porous carbon, Chem. Eng. J., 2017, 314, 50–58.
S. Poirier-Larabie, P. A. Segura and C. Gagnon, Degradation of the pharmaceuticals diclofenac and sulfamethoxazole and their transformation products under controlled environmental conditions, Sci-ence of the total environment, 2016, 557, 257–267.
A. Marchlewicz, U. Guzik and D. Wojcieszynska, Over-the-counter monocyclic non-steroidal an-ti-inflammatory drugs in environment–sources, risks, biodegradation, Water Air Soil Pollut., 2015, 226 (10).
S. Chopra and D. Kumar, Ibuprofen as an emerging organic contaminant in environment, distribution and remediation, Heliyon, 2020, 6(6).
S. N. Oba, J. O. Ighalo, C. O. Aniagor and C. A. Igwegbe, Removal of ibuprofen from aqueous media by adsorption: A comprehensive review, Science of The Total Environment, 2021, 780, 146608.
B. Czech, M. Kończak, M. Rakowska and P. Oleszczuk, Engineered biochars from organic wastes for the adsorption of diclofenac, naproxen and triclosan from water systems, Journal of Cleaner Produc-tion, 2021, 288, 125686.
N. O. Ankoro, D. Kouotou, P. K. Lunga, A. T. Godwin, N. R. Lekene, N. J. Ndi and M. J. Ketcha, Ef-fect of doping activated carbon based Ricinodendron Heudelottishells with AgNPs on the adsorption of indigo carmine and its antibacterial properties, Arabian Journal of Chemistry, 2020, 13(5), 5241–5253.
D. Huang, G. Zhang, J. Yi, M. Cheng, C. Lai, P. Xu, C. Zhang, Y. Liu, C. Zhou, W. Xue, R. Wang, Z. Li and S. Chen, Progress and challenges of metal-organic frameworks-based materials for SR-AOPs applications in water treatment, Chemosphere, 2021, 263, 127672.
A. I. Osman, A. Ayati, M. Farghali, P. Krivoshapkin, B. Tanhaei, H. Karimi-Maleh and M. Sillanpaä, Advanced adsorbents for ibuprofen removal from aquatic environments: A review, Environmental Chemistry Letters, 2024, 22(1), 373–418.
International Cocoa Organization (ICCO)., November 2023, Quarterly Bulletin of Cocoa Statistics, International Cocoa Organization (ICCO) (2023).
S. Brunauer, P. H. Emmett and E. Teller, Adsorption of gases in multimolecular layers, Journal of Am. Chem. Soc, 1938, 60, 309–319.
P. Veiga, J. da S. Schultz and T. T. Matos et al., Production of high-performance biochar using a sim-ple and low-cost method: Optimization of pyrolysis parameters and evaluation for water treatment, Journal of Analytical Apply Pyrolysis, 2020, 148, 104823.
G. Z. Zhu, X. L. Deng, M. Hou, K. Sun, Y. P. Zhang and P. Li, A comparative study on characteriza-tion and adsorption properties of activated carbons by phosphoric acid activation from corncob and its acid and alkaline hydrolysis residues, Fuel Processing Technology, 2016, 144, 255-256.
T. C. F. Silva, L. VergÜtz, A. A. Pacheco, L. F. Melo, N. S. Renato and L. C. Melo, Characterization and application of magnetic biochar for the removal of phosphorus from water, Anais da Academia Brasileira de Ciências, 2020, 92(3).
H. Deng, Y. F. Li, S. Q. Tao, A. Y. Li and Q. Y. Li, Efficient adsorption capability of banana and cassava biochar for malachite green: Removal process and mechanism exploration, Environmental Engineering Research, 2022, 27(3), 530–541.
N. A. Salem and S. M. Yakoot, Non-steroidal anti-inflammatory drug, ibuprofen adsorption using ricestraw based biochar, International Journal of Pharmacology, 2016, 12, 729-736.
Y. Ngernyen, D. Petsri, K. Sribanthao, K. Kongpennit, P. Pinijnam, R. Pedsakul and A. J. Hunt, Ad-sorption of the non-steroidal anti-inflammatory drug (ibuprofen) onto biochar and magnetic biochar prepared from chrysanthemum waste of the beverage industry, RSC advances, 2023, 13, 14712-14728.
A. Sedmihradská, M. Pohořelý, P. Jevič, S. Skoblia, Z. Beňo, J. Farták, B. Čech and M. Hartman, Py-rolysis of wheat barley straw, Research in Agricultural Engineering, 2020, 66, 8–17.
N. Rouahna, D. B. Salem, I. Bouchareb, M. Asma, O. Abdel-kader, F. Ammar, H. Noureddine and B. Raj, Reduction of crystal violet dye from water by pomegranate peel– derived efficient biochar: Influ-encing factors and adsorption behaviour, Water Air Soil Pollution, 2023, 234, 5.
S. Larous and A. H. Meniai, Adsorption of Diclofenac from aqueous solution using activated carbon prepared from olive stones, International Journal of Hydrogen Energy, 2016, 41, 10380-10390.
S. D. Maazou, H. I. Hima, M. M. M. Alma, Z. Adamou and I. Natatou, Elimination du chrome par du charbon actif élaboré et caractérisé à partir de la coque du noyau de Balanites aegyptiaca, Interna-tional Journal of Biological and Chemical Sciences, 2017, 11, 3050-3065.
R. B. N. Lekene, N. O. Ankoro and D. Kouotou, High-quality low-cost activated carbon/chitosan bio-composite for effective removal of nitrate ions from aqueous solution: Isotherm and kinetics studies, Biomass Conv Bioref, 2021.
O. Samira, Y. S. Lahiouel Salih, B. H. Setti, Y. Leila and A. Samia, Assessment of PAC’s performanc-es for theremoval of amoxicillin and paracetamol in aqueous medium, PONTE International Journal of Science and Research, 2020, 76.
N. Asma, B. Sal. Dhirar, O. Abdelkader, R. Noureddine, B. Omirserik and H-B. Ahmad, Production of biochar from Melia azedarach seeds for the crystal violet dye removal from water: Combining of hy-drothermal carbonization and pyrolysis, Bioengineered, 2023, 14, 290-306.
H. Zhao, X. Liu, Z. Cao, Y. Zhan, X. D. Shi, Y. Yang, J. L. Zhou and J. Xu, Adsorption behavior and mechanism of chloramphenicols, sulfonamides, and nonantibiotic pharmaceuticals on multi-walled carbon nanotubes, J. Hazard Mater, 2016, 310, 235-245.
S. Jodeh, F. Abdelwahab, N. Jaradat, I. Warad, S. Larous and A. H. Meniai, Adsorption of Diclofenac from aqueous solution using activated carbon prepared from olive stones, J.Assoc. Arab Univ. Basic Appl. Sci, 2016, 20, 32–38.
M. D. G. De Luna, W. Budianta, K. K. P. Rivera and R. O. Arazo, Removal of sodium diclofenac from aqueous solution by adsorbents derived from cocoa pod husks, J. Environ. Chem. Eng, 2017, 5, 1465–1474.
M. Bernardo, S. Rodrigues, N. Lapa, I. Matos, F. Lemos, M. Batista, A. Carvalho and I. Fonseca, High efficacy on diclofenac removal by activated carbon produced from potato peel waste, Int. J. Environ. Sci. Technol, 2016, 13, 1989–2000.
R. Baccar, M. Sarra, J. Bouzid, M. Feki and P. Blanquez, Removal of pharmaceutical compounds by activated carbon prepared from agricultural by-product, Chem. Eng. J, 2020, 310–317.
A. S. Liyanage, S. Canaday, C. U. Pittman and T. Mlsna, Rapid remediation of pharmaceuticals fromwastewater using magnetic Fe3O4/Douglas fir biochar adsorbents, Chemosphere, 2020, 258, 127336.
M. Zbair, M. Bottlinger and K. Ainassaari et al., Hydrothermal carbonization of argan nut shell: Functional mesoporous carbon with excellent performance in the adsorption of bisphenol A and di-uron, Waste Biomass Valor, 2020, 11, 1565–1584.
G. Y. AL-Kindi, F. H. AL Ani, N. Kh. Al-Bidri and H. A. Alhaidri, Diclofenac removal from wastewater by activated carbon, IOP Conf. Series: Earth and Environmental Science, 2021, 779.
S. Larous and A. H. Meniai, Adsorption of Diclofenac from aqueous solution using activated carbon prepared from olive stones, International Journal of Hydrogen Energy, 2016.
N. D. Suzaimi, P. S. Goh and N. A. N. N. Malek et al., Performance of branched polyethyleneimine grafted porous rice husk silica in treating nitrate-rich wastewater via adsorption, J Environ Chem Eng, 2019, 7, 103235.
M. González-Hourcade, G. Simões dos Reis and A. Grimm, Microalgae biomass as a sustainable precursor to produce nitrogen-doped biochar for efficient removal of emerging pollutants from aque-ous media, Journal of Clean Production, 2022.
J. B. Njewa, T. T. Biswick and Vunain et al., Synthesis and characterization of activated carbon from agrowastes for theremoval of acetic acid froman aqueous solution, Adsorpt Sci Technol, 2022.
M. Mhamdi, H. Galai, N. Mnasri, E. Elaloui and M. Trabelsi-Ayadi, Adsorption of lead ontosmectite from aqueous solution, Environ Sci Pollut Res, 2013, 20, 1686–1697.
M. Antunes, V. I. Esteves, R. Guégan, J. S. Crespo, A. N. Fernandes and M. Giovanela, Removal of diclofenac sodium from aqueous solution by Isabel grape bagasse, Chem. Eng. J, 2012, 192, 114-121.
M. A. Zazouli, A. Azari, S. Dehghan and R. Salmani Malekkolae, Adsorption of methylene blue from aqueous solution onto activated carbons developed from eucalyptus bark and Crataegus oxyacantha-core, Water Sci. Technol, 2016, 74, 2021–2035.
O. Abuzalat, D. Wong and M. A. Elsayed, Nano Porous Composites of Activated Carbon–Metal Or-ganic Frameworks (Fe BDC@AC) for Rapid Removal of Cr (VI): Synthesis, Adsorption, Mechanism, and Kinetics Studies, Journal of Inorganic and Organometallic Polymers and Materials, 2022, 1924–1934.
V. Gómez-Serrano, M. Adame-Pereira, M. Alexandre-Franco and C. Fernández-González, Adsorption of bisphenol A by activated carbon developed from PET waste by KOH activation, Environ Sci Pollut Res, 2021, 2, 24342–24354.
P. Nanta, K. Kasemwong and W. Skolpap, Isotherm and Kinetic Modeling on Superparamagnetic Na-noparticles Adsorption of Polysaccharide, Journal of Environmental Chemical Engineering, 2018.
R. Shan, L. Yan, K. Yang, Y. Hao and B. Du, Adsorption of Cd(II) by Mg-Al-CO3- and magnetic Fe3O4/Mg-Al-CO3-layered double hydroxides: Kinetic, isothermal, thermodynamic and mechanistic studies, J. Hazard Mater, 2015, 299, 42-49.
M. A. Adebayo, L. D. T. Prola, E. C. Lima, M. J. Puchana-Rosero, R. Cataluna, C. Saucier, C. S. Umpierres, J. C. P. Vaghetti, L. G. da Silva and R. Ruggiero, Adsorption of Procion Blue MX-R dye from aqueous solutions by lignin chemically modified with aluminium and manganese, J. Hazard Mater, 2014, 268, 43-50.
S. Keerthanan, A. Bhatnagar and K. Mahatantila, Engineered tea-waste biochar for the removal of caffeine, a model compound in pharmaceuticals and personal care products (PPCPs), from aqueous media, Environmental Technology and Innovation, 2020, 19, 100847.
A. V. Abega, H. M. Ngomo, I. Nongwe, E. H. Mukaya, P. M. A. Kouoh Sone and X. Y. Mbiandab, Easy and convenient synthesis of CNT/TiO2 nanohybrid by in-surface oxidation of Ti3+ ions and ap-plication in the photocatalytic degradation of organic contaminants in water, Synthetic Metals, 2019, 251, 1–14.
N. Kaya, Z. Yıldız Uzun, C. Altuncan and H. Uzun, Adsorption of Congo red from aqueous solution onto KOH-activated biochar produced via pyrolysis of pine cone and modeling of the process using artificial neural network, Biomass Conv Bioref, 2021.
K. Shahjalal, T. Yusaku, C. S. Ganesh, A. Md Rabiul and K. Takahiro, Development of synthetic zeo-lites from bio-slag for cesium adsorption: Kinetic, isotherm and thermodynamic studies, Journal of Water Process Engineering, 2020, 33.
M. C. Ribas, M. A. Adebayo, L. D. T. Prola, E. C. Lima, R. Cataluna, L. A. Feris, M. J. Puchana Ro-sero, F. M. Machado, F. A. Pavan and T. Calvete, Comparison of a homemade cocoa shell activated carbon with commercial activated carbon for the removal of reactive violet 5 dye from aqueous solu-tions, Chem Eng J, 2014, 248, 315-326.
J. Bayuo, K. B. Pelig-Ba and M. A. Abukari, Adsorptive removal of chromium (VI) from aqueous solu-tion unto groundnut shell, Applied Water Science, 2019, 9, 1-11.
H. Patel, Review on solvent desorption study from exhausted adsorbent, Journal of Saudi Chemical Society, 2021, 25.
T. Alsawy, E. Rashad and M. El-Qelish et al., A comprehensive review on the chemical regeneration of biochar adsorbent for sustainable wastewater treatment, j Clean Water, 2022, 5, 29.
H. Tan, R. A. Wahab, P. Y. Ong, P. S. Goh, K. Wong, Y. V. Fan and C. T. Lee, Chemical Regeneration of Spent Empty Fruit Bunch Biochar for Sodium Ion Adsorption, Chemical Engineering Transactions, 2023, 106, 313-318.
Refbacks
- There are currently no refbacks.
Copyright (c) 2026 Franck Joel MOUAFO MOUAFO
Sciences des Structures et de la Matière published by CRUFAOCI (01 BP 134, Ouagadougou 01, Burkina Faso, 1200 logements, secteur 14), is licensed under a Creative Commons Attribution 4.0 International License.